- Can pea gravel be compacted?
- What kind of gravel do you put under concrete?
- How do you prepare the ground for a concrete garage floor?
- How many inches of gravel do you need for a concrete slab?
- Is it OK to pour concrete on dirt?
- How do you prepare ground for concrete?
- Is sand a good base for concrete?
- Do you need rebar for 4 inch slab?
- Can I pour a 2 inch concrete slab?
- Do you need to put gravel under concrete?
- Why do they put foam under concrete?
- What is the best base for concrete?
- Why do you put gravel down before pouring concrete?
- Can you pour concrete over pea gravel?
- Is it cheaper to mix your own concrete?
- How much does it cost to pour a 12×12 concrete slab?
Can pea gravel be compacted?
For projects similar to yours, to reach full compaction, I always used a special gravel called washed pea gravel.
The stones are rounded, and they are the size of fat green peas.
To get full compaction, you need to do it in lifts where the material being compacted is not much more than 4 inches thick..
What kind of gravel do you put under concrete?
Backfill beneath concrete flat-work along foundation walls should be accomplished with a granular material that is uniform in size. Some fill materials, such as round stones like pea gravel, tend to be self compacting. “I recommend open-graded granular material be used,” says Tull.
How do you prepare the ground for a concrete garage floor?
Good ground preparation starts with removing the topsoil. Then, if the soil has not previously been “disturbed” (i.e., dug up), a four-inch layer (minimum) of gravel or stone should be added. (Soil that has been dug up before should be compacted.) The gravel or stone also needs to be compacted.
How many inches of gravel do you need for a concrete slab?
Excavate the slab area to a depth of about 7 inches, allowing 3 inches for a gravel base and 4 inches for concrete.
Is it OK to pour concrete on dirt?
Long story short, yes you can pour concrete over dirt.
How do you prepare ground for concrete?
Preparation is the most important aspect of pouring a concrete slab.Dig the ground down to the proper depth. … Smooth out the ground with the flat side of a rake so that you have a level surface. … Tamp the ground with a hand tamper or mechanical tamper. … Pour 2 inches of small, rounded gravel for additional drainage needs.
Is sand a good base for concrete?
Pour concrete over a solid, well-drained base of sand or gravel over clay and other poorly draining soils to provide even support.
Do you need rebar for 4 inch slab?
No, you do not need rebar for a 4-inch slab of concrete on grade. A 4-inch-thick slab cast on the ground and in permanent contact with it will float and rebar is not required. Rebar is recommended on concrete measuring 5 – 6 inches thick.
Can I pour a 2 inch concrete slab?
If done properly, new concrete can often be poured right over an existing slab. For this to be feasible, the contractor needs to pour at least 2 inches thick, use smaller aggregate, and incorporate reinforcement such as welded wire mesh or fiber mixed into the concrete.
Do you need to put gravel under concrete?
Whether you pour concrete for a walkway or patio, a strong gravel base is required to prevent the concrete from cracking and shifting. Gravel is especially important in clay soil because it doesn’t drain well, which results in water pooling under the concrete slab and slowly eroding the soil as it finally drains.
Why do they put foam under concrete?
Concrete contractors learned that a layer of poly helps to keep a slab dry, because it stops upward vapor diffusion from the soil. … The foam layer isolates the room-temperature slab from the cold soil under the slab.
What is the best base for concrete?
The base course material, according to ACI 302, “Concrete Floor and Slab Construction,” should be “compactible, easy to trim, granular fill that will remain stable and support construction traffic.” ACI 302 recommends material with 10 to 30% fines (passing the No. 100 sieve) with no clay, silt, or organic materials.
Why do you put gravel down before pouring concrete?
Because concrete is a very porous material, it will absorb any moisture that it contacts. This can cause pooling. Without crushed stone, pooling water will settle under it and erode your slab. Adding a layer of crushed stone will add proper drainage, as well as create a barrier between your slab and the ground.
Can you pour concrete over pea gravel?
Concrete on pea gravel. A slab with living area over it usually has a gravel bed to facilitate drainage. It should be ok to pour concrete over your gravel walk although you might want to give the concrete a little more depth along the sides. you might want to give the concrete a little more depth along the sides.
Is it cheaper to mix your own concrete?
One of the least expensive ways to get concrete is to mix your own. You can buy bags of the mix from a home improvement store. Typically, you only have to add water for it to be ready to pour. However, it is important to get the ratio right and to mix the concrete thoroughly.
How much does it cost to pour a 12×12 concrete slab?
The average cost to pour a 12×12 concrete slab that is 4” thick is between $888 and $1,584, with professional labor and materials included.